We have some hot news! We’re launching a new product, our AdBlue Emulator product range now expanded with a brand new V3 generation emulator. This AdBlue emulator designed to support the most complicated Volvo and Renault EURO 6 vehicles that are equipped with a retarder system. Keep in mind this emulator is designed to work only with vehicles equipped with retarder and only the EURO 6 versions, other models without retarder or EURO 5 and older versions not supported by this device. The device is a newly developed version of the previous emulator generation that was designed also for EURO 6 Volvo vehicles with a retarder system.
As always we offer a high-quality product. Designed, developed and manufactured in the European Union with an option of next business day delivery to any European Union country (worldwide shipping takes a little bit longer, about two business days). We will provide all necessary installation instructions and twelve-month limited warranty. If you need more information please contact us.
Continue reading New product! Volvo-Renault V3 AdBlue Emulator for EURO 6 vehicles with retarder
NOx Sensor Emulator DAF EURO 5 is a brand new product that complements our emulator products range. As usual, we are trying our best and this device also designed, developed and manufactured in the European Union. It is assembled from the highest quality components to minimise any fault caused by ambient temperature fluctuations and heat from the exhaust pipes since this emulator must be installed in the original NOx sensor module box.
NOx Sensor Emulator DAF EURO 5 details
First things first, this device emulates both (two) NOx sensors (upstream and downstream), so it covers NOx emissions control completely. It means that the emulator will provide necessary data to the ECU needed for proper work of engine even if the catalytic converter is damaged or removed. No more OBD (On-Board Diagnostics) DTC (Diagnostic Trouble Code) errors, no engine limp mode activations or rough run. The engine will work smoothly with normal fuel consumption level. Installation is easy and doesn’t require special knowledge or equipment. We will provide installation manuals and twelve-month warranty. Continue reading NOx Sensor Emulator for DAF EURO 5 vehicles is now available
AdBlue Emulator V5 is now again on stock and we can offer it in large quantities. All large pre-orders will be shipped within two business days and there will be no shipping delay for all new orders. All kits of AdBlue Emulator V5 available (10, 20, 50 and 100 units per kit). Just to remind you, this emulator is designed for EURO 5 vehicles made by DAF, Iveco, MAN, Mercedes-Benz, Renault, Volvo and FORD.
- SCR Emulator V4 NOx emulates SCR system completely;
- Emulates DEF fluid level sensor;
- Emulates DEF fluid temperature sensor;
- Emulates NOX sensor;
- Emulates exhaust temperature sensor;
- Emulates NOX sensor;
- There will be no engine power loss;
- No diagnostic errors at all on SCR module;
- User friendly (easy to install and uninstall);
- Saves your money, equipment and time;
Continue reading AdBlue Emulator V5 again on stock and available in all kits
MAN EURO 6 SCR Emulator product get some improvements. But first things first. The main improvement that MAN EURO 6 SCR Emulator now available only with the direct connection adapter. It means that you don’t need mess around your truck for hours to connect the emulator. Just plug in and drive, anyway don’t forget to read the installation manual because there are several recommended steps to do.
Now you think, wow they added a plug to the kit, and now emulator costs almost as my truck? No, absolutely no. We dropped the price, and it’s way cheaper than it was previously without the plug. From now MAN EURO 6 SCR Emulator including the direct connection plug costs only 119 EUR. Yes, only 119 EUR for the EURO 6 emulator.
We have plenty of them in stock so grab one yours because this is the best price on the market for such type of emulator. As always we offer next business day delivery over the European Union and a little bit longer delivery worldwide to any country. All emulators have a twelve-month warranty, developed and manufactured in the EU. For more information contact us, and we will provide all information that you might need.
Continue reading MAN EURO 6 SCR emulators with huge discount and some improvements
EURO 6 Volvo trucks are quite common on roads. We have good news for all owners of EURO 6 Volvo trucks since we are making a limited time offer for EURO 6 SCR Emulator Volvo V2 product. Now you can purchase this state-of-art emulator just for 99 euros. This device supports all Volvo trucks with the highest at this moment emission control systems (except models with retarder system). These emulators developed and manufactured in Europe, and we offer next business day delivery to any European Union country (with 12 months warranty). We will send emulators prepared for your trucks so don’t forget to provide the DEF (Diesel Exhaust Fluid) tank capacity data (usually 60 or 90 litres, but you must check it yourself to avoid any mistakes and compatibility issues). Please don’t try this emulator on other trucks like Volvo EURO 5 or EURO 4 and trucks made by other manufacturers, and it could harm the emulator and the car itself. Also, don’t forget to read the installation manual and follow all steps carefully. Don’t forget, we have SCR emulators for all vehicles, check out our online store, and you’ll find any SCR emulator that you need.
EURO 6 Emulator for Volvo
Attention! SCR emulators are illegal in some countries. You should check your local laws or laws of those countries that you might cross with your vehicle. SCR emulator alters SCR system thus makes the vehicle to produce higher exhaust gas emissions. EURO 6 and EURO 5 vehicles equipped with SCR emulator device will no longer match those EURO standards. Our SCR emulators designed for countries where environmental rules are less strict, and there are no requirements for vehicles to satisfy EURO 6 or EURO 5 regulations. By purchasing any SCR emulator, you assume full responsibility for the use of the device. It’s your personal decision to use an emulator or not. We will not accept any liability for any consequences associated with usage of SCR emulator devices.
EURO 6 SCR Emulators are getting more popular every day, so we decided to make it possible to buy ten or twenty modules at once for a reduced price. Here’s the deal, we selected three most popular EURO SCR Emulators (EURO 6 Volvo, EURO 6 Iveco Eurocargo and EURO 6 Iveco Stralis) and now you can purchase them in bulk kits of ten and twenty units. They usually are available for 149 EUR (EURO 6 Volvo and EURO 6 Iveco Eurocargo versions) and 169 EUR (EURO 6 Iveco Stralis, this one comes with direct connection plug sets). We offer same EURO 6 SCR Emulators for a lower price (check out the table below).
EURO 6 SCR Emulators (prices per unit)
|Price table||EURO 6 Volvo||EURO 6 Iveco Eurocargo||EURO 6 Iveco Stralis|
|Single unit||149 EUR (per unit)||149 EUR (per unit)||169 EUR (per unit)|
|Bulk kit of ten units||129,90 EUR (per unit)||129,90 EUR (per unit)||139,90 EUR (per unit)|
|Bulk kit of twenty units||109.95 EUR (per unit)||109.95 EUR (per unit)||119.95 EUR (per unit)|
Continue reading EURO 6 SCR Emulators now available in bulk kits of ten and twenty units
AdBlue Emulator for Scania EURO 4 and EURO 5 type vehicles available in several options. Today we officially discontinuing the support of Scania vehicles on AdBlue Emulator V5 modules. So from today, we will pre-program only V4 emulator modules to support the Scania EURO 4 and EURO 5 trucks.
Why are we doing this? Well, the main reason is the complex and too complicated installation process. We have several cases were our customers have faced some serious trouble while installing V5 emulators on Scania EURO 4 and EURO 5 vehicles.
So if you want AdBlue Emulator for Scania EURO 4 or EURO 5 truck we highly recommend you to use the V4 module instead. V4 emulators are easier to install, offers excellent compatibility with Scania EURO 4 and EURO 5 vehicles.
Moreover, V4 modules have a more extensive vehicle support list and have a newer firmware than V5 modules. Continue reading AdBlue Emulator for Scania EURO 4 and EURO 5 vehicles
AdBlue emulators are devices intended to take over control of the SCR (Selective Catalytic Reduction) system. SCR system is responsible for control of exhaust system on the modern truck, bus or other vehicles. A lot of the vehicles made and used in Europe equipped with diesel engines. Older diesel engines had a simple catalytic converter called DOC (Diesel Oxidation Catalyst). This type of catalytic converter is common for all compression-ignition engines. Diesel oxidation catalytic converters made from ceramic core coated with palladium, platinum and aluminum oxide. These coatings serve as catalysts to oxidize the remains of the hydrocarbons and carbon monoxide in the exhaust gasses with oxygen to form carbon dioxide and water. But at certain conditions diesel engines may produce significant amounts of NOx (Mono-Nitrogen Oxides) emissions. Mono-nitrogen oxides NO and NO2 (nitric oxide and nitrogen dioxide) considered as pollutants and led to the introduction of SCR (Selective Catalytic Reduction) systems.
Selective Catalytic Reduction system
Selective Catalytic Reduction (SCR) system is a device that has one purpose, to reduce the quantity of Mono-Nitrogen Oxides (NOx) in engine exhaust gasses. While diesel oxidation catalytic converter (DOC) is capable of reducing emissions of hydrocarbons and carbon monoxide, SCR is capable of reducing NOx emissions. SCR catalytic converter core usually made from ceramic (titanium oxide) and coated with oxides of such metals as tungsten, vanadium, molybdenum and other precious or rare metals.
Anyway, this type of catalytic converter needs an additional component to perform necessary reduction reaction. The required reduction reaction is only possible by adding a solution of anhydrous ammonia, aqueous ammonia or urea. This additive called DEF (Diesel Exhaust Fluid). The most popular DEF solution on the market is AdBlue. AdBlue is a registered trademark of German Association of the Automotive Industry (VDA). That’s why emulators of SCR systems often called AdBlue Emulators. Continue reading AdBlue emulators and SCR systems – everything you need to know